ElectricMotorcycleForum.com

I had same issue last year (melted headlight)
It was replaced under warranty... But with more than 3 month delay... Zero as very suspicious and took lot of time to accept warranty replacement.
I had stock light but replaced now with led. My dealer installed led with fan... So now each time i start the bike, there is a little noise and some vibrations i can feel in my hands

new colors replace some old ones ?

just use the battery voltage.

So easy when i'm riding :-p

Resting voltage under 97 volts and you are getting close.  93 volts should be considered empty.  88 is as low as you can get but that means many miles under 20 mph.  there is less than 1% between 93 and 88.  116 is full and 102-103 is 50%.

Very user friendly and so easy to remember 

But i will use your indications next time i travel, to check if the voltage is correct 

got it ! Thank you for pointing it

The glass of my headlight have been melted some times ago (dont know why, except that the glass is always very hot when the bike is ON...)

Warranty did the job and i have got a new one. I asked my dealer to replace the H4 by a led. He didnt told me than there is a f**ing fan with this light.

LED light is always cold, Is there any reason to add a fan Can i disconnect it ? It is very loud and make vibration in the handlebar !

I had think same for 1 year... until few weeks ago when it goes to 100% all the time...

No everything is normal (if you except the other bug i have posted here : http://electricmotorcycleforum.com/boards/index.php?topic=7404 but both was not occurs together. I had the fan issue, and at least 1 week after the battery % issue).

I key ON, fan goes to 100% and sound loudly. Lights goes on and off normally on the bike display. Fan stay at 100% during all my travel and stop only when i key off.

Zero use same tires for S & SR :
- Pirelli Diablo rosso II in 2017
- Pirelli Sport Demon in 2016

My 2016 sport demon last long time. At 19 000 km, Rear was used, front was still good. Done many (more than 5) track days with theses tires.
Changed both at 19 000km for Bridgestone S20 evo.

Since some weeks, the fan of my zero (located inside the battery block ? didnt noticed the bike have a fan before !) is continuously running at 100% of speed, during all the time the bike is keyed ON.

It generate a hearable fan sound, and also small vibration in the handlebars. Is it normal ? Due to last firmware update ?